Journal of the Korean Ceramic Society (한국세라믹학회지)

The Korean Ceramic Society (한국세라믹학회)
권호 표지

Effect of Sulfate on the Reaction of 3CaO.SiO2 Formation in Presence of Clinker Melt and Its Appearance in Clinker

$SO_3$가 클링커 액상이 존재하는 $3CaO.SiO_2$ 생성반응에 미치는 영향과 클링커안에서의 존재상태

  • 정해문 (한양대학교 공과대학 무기재료공학과) ;
  • 한기성 (인하대학교 공과대학 요업공학과) ;
  • 최상흘 (한양대학교 공과대학 무기재료공학과)
  • Published : 1993.01.01
Download PDF
⟨ Previous Next ⟩

Abstract

Effect of sulfate on the reactionof C3S formation in presence of clinker melt and its appearance in clinker were investigated, using (NH4)2SO4 and CaSO4 as sulfate sources. When (NH4)2SO4 and CaSO4 were added, both showed the similar results, 1.0wt% of sulfate could promoted the reaction of C3S formation, however for its content of more than 2.0wt%, the formation of C3S was prevented. Residual limit of sulfate to C3S formation is about 1.4wt%. Appearances of sulfate were C4A3l and CaSO4 in interstitial phase. For the addition of (NH4)2SO4 or CaSO4 of 20wt%~4.0wt%, C3S grains showed the hypertrophic growth. We might consider that, because sulfate reduced the surface tension and viscosity of the clinker melt, C3S crystals were precipitated below 140$0^{\circ}C$, and the crystlas of C3S were coalesced and linked in the same crystallographical direction with increasing temperature becuase of their rapid growth rate.

Keywords

References

  1. 5th Inter.Symp.Chem.Cem. v.1 Mechanisms and Kinetics of Portland Cement Clinker Formation for an Example of the Solid State Reaction in the Presence of Liquid Phase R.Kondo;S.H.Choi
  2. Cem.Con.Res. v.8 Rate of Alite Formation in Clinker Sandwiches N.H.Christensen;O.L.Jepson
  3. 6th Inter.Cong.Chem.Cem.Principal Paper The Phase Composition of Portland Cement Clinker W.Gutt;W.Nurse
  4. 7th Inter.Cong.Chem.Cem. v.Ⅰ Influence of the Nature and Preparation of Raw Materials on the Reactivity of Raw Mix R.Bucchi
  5. 6th Inter.Cong.Chem.Cem. The Mechanism of Clinker Formation Process and Ways of Modification Y.M.Butt;V.V.Timashev
  6. Review of the 34th General Meeting-Technical Session Held in Tokyo The Sulfur Cycle in Cement Kilns F.P.Glasser
  7. Cem.Con.Res. v.10 Sulphates in Cement Clinkering;Immiscibility between Sulphate and Oxide Melts at 1350℃ F.P.Glasser;J.Marr
  8. Trans.J.Brit.Ceram.Soc. v.67 Studies of Role of Calcium Sulphate in the Manufacture of Portland Cement Clinker W.Gutt;M.A.Smith
  9. Cem.Tech. v.2 Studies of Sulphates in Portland Cement Clinker W.Gutt;M.A.Smith
  10. Zem.Kal.Gip. v.38 Influence of Alkalies and Sulphur on the Properties of Cement;Part-Ⅰ J.Strunge;D.Knofel
  11. ibid v.38 Influence of Alkalies and Sulphur on the Properties of Cement;Part-Ⅱ J.Strunge;D.Knofel
  12. ibid v.39 Influence of Alkalies and Sulphur on the Properties of Cement;Part-Ⅲ J.Strunge;D.Knofel
  13. ibid v.43 Influence of Alkalies and Sulphur on the Properties of Cement;Part-Ⅳ J.Strunge;D.Knofel
  14. 8th Inter.Cong.Chem.Cem. v.1 Relationship of Processing Parameters to Clinker Properties;Influence of Minor Components I.Maki
  15. J.Korean Ceramic Society v.12 no.2 On the Rapid Hardening Cement(Ⅰ) K.S.Han;S.H.Choi;S.M.Han;I.Y.Seo
  16. Cem.Con.Res. v.9 Electron Microprobe Analysis of Portland Cement Clinkers A.Ghose;P.Barnes
  17. Microscopic Examination and Interpretation of Portland Cement and Clinker D.H.Campbell