Journal of Animal Environmental Science (한국축산시설환경학회지)

The Korean Society of Animal Environmental Science & Technology (한국축산환경학회)
권호 표지

Conducted to Verify the Effect of Chlorine Dioxide (ClO2) on Odor Reduction at a Commercial Swine Facility

이산화염소 가스분무에 의한 양돈장 악취저감 효과

  • Song, J.I. (National Livestock Research Institute, R.D.A.) ;
  • Jeon, J.H. (National Livestock Research Institute, R.D.A.) ;
  • Park, K.H. (National Livestock Research Institute, R.D.A.) ;
  • Yoo, Y.H. (National Livestock Research Institute, R.D.A.) ;
  • Kim, D.H. (Gyeongnam National University of Science and Technology)
  • Received : 2011.11.01
  • Accepted : 2011.12.29
  • Published : 2011.12.30
Download PDF
⟨ Previous Next ⟩

Abstract

This study was conducted to verify the effect of chlorine dioxide ($ClO_2$) on odor reduction at a commercial swine facility consisting of a windowless piglet barn and a grower/fattening barn. The windowless piglet barn used a duct ventilation system. Air velocity at very below the upper duct was 4.53 m/s. Air velocity at the lower space around the living space of pigs in the grower/fattening barn was 0.26 m/s. $NH_3$ concentration was around 9ppm and less than 3 ppm before and after the $ClO_2$ spraying, respectively, which was over 70% reduction. There was no $H_2S$ detection. $NH_3$ concentrations measured in the windowless grower/fattening barn and at the exhausted air were 26 ppm and 11ppm, respectively. $NH_3$ concentration at a biocurtain outside was less than 1 ppm. Hence, $ClO_2$ spraying at windowless barns was effectively decreased malodor such as $NH_3$.

본 연구는 무창 자돈사 및 육성 비육돈사에 대한 악취 제어를 위하여 이산화염소 가스를 이용한 악취 제어 효율을 검증하고자 하였다. 본 실험은 일반농장에서 실시하였으며 실험결과는 다음과 같다. 1. 무창 자돈사는 환기시스템이 덕트입기 방식이어서 즉, 상부 덕트 바로 하부에서의 공기속도는 4.53 m/s로 나타나 입기구를 통하여 들어오는 공기에 의하여 돈방내 전체적인 공기의 흐름이 나타나 효과적으로 환기가 되었다. 그리고 무창 육성비육사는 공기속도의 분포 흐름은 돼지의 생활공간 (하부)에서는 0.26 m/s로 나타났다. 2. 무창 자돈사내부에서의 암모니아 가스는 이산화염소 가스를 분무하기 전에는 9 ppm 전후로 측정되었으나, 이산화염소 가스 분무후 돈사내 암모니아 농도는 3 ppm 이하로 나타나 70% 이상 저감되었지만 황화수소는 검출이 거의 되지 않았다. 3. 무창육성비육돈사의 환기시스템에 의한 유해가스 (암모니아)의 농도를 분석한 결과로써, 돈사내부는 $26mg/{\ell}$로 유지되었지만 돈사외부로 배출된 가스는 이산화염소 가스와 혼합되어 11 ppm으로 감소되었으며 바이오 커텐 외부에서의 측정 결과 1 ppm 이하로 측정되어 암모니아 가스가 거의 측정되지 않았다. 이상의 실험결과를 종합해 볼 때 무창 돈사에 있어서 이산화염소 가스 분무에 의한 돈사 내외부에서 암모니아 등의 악취를 외부에 휘산시키는 농도를 저하시킬 수 있음을 알 수 있었다.

Keywords

References

  1. Bohn, H. L. 1996. "Biofilter Media", Air Waste Manage. Assoc., 89th Annual Meeting & Exhaubition, June 23-28, 96-WP 87A. 01.
  2. Bottcher, Munilla, Baughman, and Keener. Designs for Windbreak Walls for Mitigating Dust and Odor Emissions From Tunnel Ventilated Swine Buildings. In: Swine housing Proceedings of the First International Conference, Des Moines, Iowa, USA, 9-11, October 2000 (2000): 174-181.
  3. Chastain, J., "Odor control", Agr. Biolog. Eng., Clemson Univ. 1997. p.342.
  4. Chastain, J.P., and F.J. Wolak. 2000. Application of a Gaussian Plume Model of Odor Dispersion to Select a Site for Livestock Facilities. Proceedings of the Odors and VOC Emissions 2000 Conference, sponsored by the Water Environment Federation, April 16-19, Cincinnati, OH., 14 pages, published on CD-ROM.
  5. Donham, K. J. 1997. Human health and safety for workers in livestock housing. In: Latest developments in livestock housing. Proceedings of Commission Internationale du Genie Rural, Section 2 Seminar. 22-26.
  6. Jacobson, L. D., H. Guo, D. R. Schmidt, R. E. Nicolai, J. Zhu, and K. A. Janni. 2000. Development of an Odor Rating System to Estimate Setback Distances from Animal Feedlots: Odor From Feedlots-Setback Estimation Tool (OFFSET). Paper No. 004044, Presented at the ASAE International Meeting, Milwaukee, WI, July 9-12. ASAE, St. Joseph, MI. 27 p. 488.
  7. Janni, K., Jacobson, L. D., Bicudo, J. R., Schmidt, D. and Guo, H. 2000). Livestock and poultry odor workshop II. biofilters, covers, OFFSET, and odor management plans. Dept. of Biosystems and Agricultural Engineering, University of Minnesota, St. Paul, MN. 100 pp.
  8. John R. Hill and W. B. Sainsbury. 1995. The Health of Pig. Producted by Longman Singapore Publishers (Pte) Ltd. p.275. Printed in Singapore.
  9. MWPS. 1990. Mechanical ventilating systems for livestock housing, MWPS-32, Midwest Plan, Iowa State University, Ames.
  10. Nicolai, R. E., C. J. Clanton, K. A. Janni. 2002. Ammonia Removal and Nitrogen Accumulation in Biofilter Media. In Proceedings of USC-TRG Conference on Biofiltration, 119-129. Newport Beach, California. October 31-November 1.
  11. NIOSH (National Institute of Occupational Safety and Health). 2010. Centers for Disease Control and Prevention 1600 Clifton Rd. Atlanta, GA 30333, USA.
  12. Yuwono, A. and P. Schulze Lammers. 2004. Odor pollution in the environment and the detection instrumentation. Agricultural Engineering International: the CIGR Journal of Scientific Research and Development. Invited Overview Paper. Vol. VI.
  13. 류희욱, 조경숙, 이태호, 허 목. 2004. 양돈 시설 악취 관리: III. 악취 제어 기술. 한국냄새환경학회지. 3(1):1-11.