Journal of the Korean Geotechnical Society (한국지반공학회논문집)

Korean Geotechnical Society (한국지반공학회)
권호 표지
DOI QR코드

DOI QR Code

A Case Study of Post-Grouted Drilled Shaft in Weathered Rock

풍화암소켓 대구경 현장타설말뚝의 선단보강그라우팅 사례

  • Received : 2010.04.26
  • Accepted : 2011.05.10
  • Published : 2011.06.30
Download PDF
⟨ Previous Next ⟩

Abstract

Post-grouting for the drilled shaft is known to remarkably increase the end bearing capacity of pile by consolidating and reinforcing the disturbed ground containing slime around the pile tip. However, the general design guideline for post-grouting has not been established yet in Korea. Especially in the domestic application, the post-grouting is employed just for repairing the pile with unacceptable resistance rather than for increasing the design resistance of pile. Therefore, little is reported about the effect of post-grouting on the pile resistance itself. In this study, the effect of post-grouting on the resistance of drilled shafts installed in the weathered rock in Korea was estimated by performing the bi-directional load tests on the piles with and without the post-grouting. The test results presented that the initial slope of end bearing-base displacement curve in the pile with post-grouting was 4 times higher than that without post-grouting. At the acceptable settlement (1% of pile diameter), the end bearing capacities of piles with and without the post-grouting were estimated to be 12.0 MPa and 7.0 MPa, respectively, which indicate that the post-grouting could increase the end bearing resistance of pile in weathered rock more than 70%.

현장타설말뚝의 포스트그라우팅 기법은 말뚝 시공시 발생하는 슬라임과 굴착으로 인해 교란된 원지반을 압축 및 보강함으로써 기초의 선단지지력을 현저히 증강시키는 것으로 알려져 있다. 그러나 현재까지 국내외적으로 통용되는 설계지침 또는 시방은 없는 상태이며, 특히 국내에서는 말뚝 포스트그라우팅 기법이 설계지지력 증강 목적이 아닌, 소요지지력에 미달되는 말뚝에 대한 보수보강의 개념으로 이해되고 있어, 그 효과에 비해 관련 연구 및 실용화 실적이 미비한 실정이다. 본 연구에서는 포스트그라우팅 기법의 국내 풍화대소켓 현장타설말뚝에의 적용성을 검증하기 위해 풍화암 근입 대구경 현장타설 콘크리트말뚝 시공 현장을 선정하여 포스트그라우트 시험시공을 실시하였다. 또한 포스트그라우팅 말뚝, 그리고 인접한 미보강 말뚝에 대한 정재하시험을 수행함으로써, 포스트그라우팅이 현장타설말뚝의 축방향 지지력 증강에 미치는 효과를 정량적으로 비교분석해 보고자 하였다. 정재하시험 결과, 선단보강 말뚝 선단하중-침하곡선의 초기기울기가 미보강 말뚝 선단히중-침하곡선의 기울기에 비해 4배 이상 증가였으며, 허용침하량(1%D) 기준으로 보강 및 미보강 말뚝의 선단지지력은 각각 12.0MPa, 7.0MPa로 나타나, 포스트그라우팅 적용 후 말뚝의 허용선단지지력이 70% 이상 증가하는 것을 확인하였다.

Keywords

References

  1. 대한토목학회 &교량설계핵심기술연구단 (2008), 도로교 설계기준 해설, pp.692-697.
  2. 대림산업 (2007), 대심도 연약지반의 공간적 지반특성화 및 풍화 대소켓 장대 현장타설말뚝기초의 실용화 기술개발.
  3. 정성준 (2010), Calibration of resistance factors of load and resistance factor design for drilled shafts embedded in weathered rock, 서울 대학교 박사학위 논문.
  4. 설훈일 (2008), Load transfer analysis of rock-socketed drilled shafts by considering coupled soil resistance, 연세대학교 박사학위논문.
  5. 전경수 (2000), 풍화암에 근입된 현장타설말뚝의 연직 및 횡방향 지지거동 분석, 서울대학교 박사학위 논문.
  6. 권오성 (2004), 암반의 풍화도가 암반근입말뚝의 지지거동에 미치는 영향, 서울대학교 박사학위 논문
  7. Kwon, O.S., Choi, Y.K, Kwon, O.K., Kim, M.M. (2005), "Comparison of the bi-directional Load test with the top-down load test", Journal of the Transportation Research Board No.1936, pp.108-116. https://doi.org/10.3141/1936-13
  8. Bruce, D.A. (1986), "Enhancing the performance of large diameter piles by grouting", Parts 1 and 2, Ground Eng., May and June.
  9. Mullins, G., Winters, D., and Dapp, S. (2006), "Predicting end bearing capacity of post-grouted drilled shaft in cohesionless soils", Journal of Geotechnical Engineering and Geoenvironmental Engineering, ASCE, Vol.132, No.4, pp.478-487. https://doi.org/10.1061/(ASCE)1090-0241(2006)132:4(478)
  10. Mullins, G., Dapp, S., and Lai, P. (2000), "Pressure-Grouting Drilled Shaft Tips in Sand", New Technological and design Developments in Deep Foundations, Geotechnical Special Publications No.100, ASCE.
  11. Thasnanipan, N., Aye, Z. Z., Submaneewong, C. (2004), "Effectiveness of Toe-Grouting for Deep-Seated Bored Piles in Bangkok Subsoil", Geo-Support 2004: Drilled Shafts, Micropiling, Deep Mixing, Remedial Methods, and Specialty Foundation Systems, Geotechnical Special Publication No. 124, ASCE.
  12. Dapp, S. D., Mullins, G. (2002), "Pressure Grouting Drilled Shaft Tips: Full-Scale Research investigation for silty and shelly sands", Deep Foundations 2002: An international perspective on theory, design, construction, and performance, Geotechnical Special Publication No. 116, Vol. 1, ASCE, pp.335-350.
  13. Fernandez, A. L., Pando, M. A., and King, P. G. (2007), "Load test program to validate model for post grouted drilled shafts", Contemporary Issues in Deep Foundations, Geotechnical Special Pub. No.158, ASCE.
  14. Safaqah, O., Bettner, R., Zhang, X. (2007), "Post-Grouting of Drilled Shaft Tips on the Sutong Bridge: A Case History", Contemporary Issues in Deep Foundations, Geotechnical Special Pub. No.158, ASCE.
  15. Thasnanipan, N., Aye, Z. Z., Submaneewong, C. (2004), "Effectiveness of Toe-Grouting for Deep-Seated Bored Piles in Bangkok Subsoil", Geo-Support 2004: Drilled Shafts, Micropiling, Deep Mixing, Remedial Methods, and Specialty Foundation Systems, Geotechnical Special Publication No. 124, ASCE.
  16. Reese, L.C., and O'Neill, M.W. (1988), "Drilled shaft: Construction Procedures and Design methods", FHWA Publication No. FHWAHI- 88-042 or ADSC Publication No. ADSC-RL-4, McLean, Virginia.
  17. Ho, C. E. (2003), "Base Grouted Bored Pile on Weak Granite", Grouting 2003: Grouting and Ground Treatment, Geotechnical Special Publication No.120, ASCE. pp.716-727.
  18. Castelli, R. J., Wilkins, E. (2004), "Osterberg Load Cell Test Results on Base Grouted Bored Piles in Bangladesh", Geo-Support 2004: Drilled Shafts, Micropiling, Deep Mixing, Remedial Methods, and Specialty Foundation Systems, Geotechnical Special Publication No. 124, ASCE.
  19. King, P., Fernandez, A., and Pando, M. A. (2009), "Post Grouted Drilled Shafts - A Comprehensive Case History from Texas", Contemporary Topics in Deep Foundations, Geotechnical Special Publication No. 185, ASCE., pp.31-38.
  20. Ruiz, M.E., Pando, M.A. (2009), "Load Transfer Mechanism of Tip Post-Grouted Drilled Shafts in Sand", Contemporary Topics in Deep Foundations, Geotechnical Special Publication No. 185, ASCE., pp. 23-30.
  21. Pooranampillai, F., Elfass, S., Vanderpool, W., and Norris, G. (2009), "Large-Scale laboratory Study on the Innovative Use of Compaction Grout for Drilled Shaft Tip Post Grouting", Contemporary Topics in Deep Foundations, Geotechnical Special Publication No. 185, ASCE., pp.39-46.
  22. Teparaksa, W. (2002), "Behavior and Performance of Instrumented Barrette Piles in Bangkok Subsoils", Deep Foundations 2002: An international perspective on theory, design, construction, and performance, Geotechnical Special Publication No. 116, ASCE, pp. 1305-1317.