Journal of the Korea Academia-Industrial cooperation Society (한국산학기술학회논문지)

The Korea Academia-Industrial cooperation Society (한국산학기술학회)
권호 표지
DOI QR코드

DOI QR Code

Evaluation on Mix Characteristics of Concrete Using Fine Sand of Nakdong-River

낙동강 세사를 사용한 콘크리트의 배합특성 평가

  • Bae, Su-Ho (Department of Civil Engineering, Andong National University) ;
  • Kim, Chang-Duk (Department of Civil Engineering, Andong National University) ;
  • Lee, Seung-Han (Department of Civil Engineering, Keimyung University)
  • Received : 2013.01.28
  • Accepted : 2013.03.07
  • Published : 2013.03.31
Download PDF
⟨ Previous Next ⟩

Abstract

The purpose of this experimental research is to suggest a base data to utilize the fine sand of Nakdong-River actively as an alternative aggregate for concrete. For this purpose, after the typical fine sand samples were collected at the mid stream and down stream of main stream of Nakdong-River, the physical properties of them and the mix characteristics of concrete using those were estimated. As a result, it was observed from the test result that mix characteristics between concrete using fine sand and concrete using well-graded reference sand made little differences since unit water content and unit cement content of concrete using fine sand increased only a little than those of concrete using reference sand for specified compressive strength.

지속적인 경제성장에 따른 콘크리트 구조물의 급증으로 양질의 하천모래가 고갈됨에 따라 콘크리트용 대체 골재 개발이 필요한 실정이다. 따라서 이 연구의 목적은 낙동강 세사를 콘크리트용 대체골재로서 적극적으로 활용하기 위한 기초자료를 제시하는 것이다. 이를 위하여 세사 분포지역인 낙동강 본류의 중 하류에서 세사 시료를 채취한 후, 이들의 밀도, 입도, 단위용적질량 및 0.08mm체 통과량 등의 물성 평가와 세사를 사용한 콘크리트의 배합특성으로 설계기준강도에 대한 단위수량 및 단위시멘트량을 평가하였다. 그 결과, 세사를 사용한 콘크리트의 설계기준강도에 대한 단위수량 및 단위시멘트량은 입도가 좋은 기준모래를 사용한 콘크리트의 경우보다 크게 증가하지 않는 것으로 나타나, 전자와 후자 사이의 배합특성은 별 차이가 없는 것으로 나타났다.

Keywords

References

  1. Y. J. Oh, "The Influence of Fineness Modulus of Fine Aggregate on the Quality Characteristics of Concrete According to Mixing Method", Dept. of Civil Engineering Graduate School of Industry Pusan National University, 2010.
  2. Ministry of Land, Transport and Maritime Affairs, "The 4th Basic Plan for Supply and Demand of Aggregates", 2008.
  3. Korea Cement Association, "Main Contents of Solution of instability for Supply and Demand of Aggregates", 2005.
  4. Y. S. Chung, S. H. Bae, J. H. Park, "Experimental Study on Physical Properties of High-Strength Concrete Using Sea Sand", Journal of the Korea Concrete Institute, Vol. 8, No. 3, pp. 219-229, 1996.
  5. C. W. Baek, H. S. Kim, C. B. Park, J. Y. Jeun, C. S. Choi, D. H. Ryu, "Influence of Qualities of Crushed Sand on the Properties of Concrete using Fine Mixture Aggregate", Proceedings of the Korea Concrete Institute, Vol. 19, No. 1, pp. 621-624, 2007.
  6. S. H. Lee, J. W. Shim, "Enactment Provision of Recycled Aggregate Concrete", Magazine of the Korea Concrete Institute, Vol. 22 No. 1, pp. 33-35, 2010.
  7. K. C. Oh, J. Y. Kim, D. Y. Yang, J. Y. Lee, S. S. Hong, J. C. Kim, "A Study on the Physical Properties of Fine Aggregates of Bonghwang-cheon in the Geum River Basin, Korea", The Korea Journal of Quaternary Research, Vol. 21, No. 1, pp. 1-14, 2007.
  8. S. J, Choi, Y. Jeoung, C. S. Park, B. J. Oh, B.C. Yeu, M. H. Kim, "An Experimental Study on the Properties of Crushed Sand in Capital Region and Concrete according to the Replacement Ratio of Crushed Sand", Journal of the Korea institute of Building construction, Vol. 5, No. 1, pp. 63-68, 2005. https://doi.org/10.5345/JKIC.2005.5.1.063
  9. J. I. Park, S. H. Bae, S. O. Kwon, C. D. Kim, S. H. Lee, "Aggregate Utilization Estimation of River Sand according to Typical Location of Main Stream of Nakdong-River", Journal of the Korea Academia-Industrial cooperation Society, Vol. 13, No. 8, pp. 3719-3725, 2012. https://doi.org/10.5762/KAIS.2012.13.8.3719
  10. KS F 2504, "Testing method for density and absorption of fine aggregate", Korean Standards Association, 2007.
  11. KS F 2502, "Standard test method for sieve analysis of fine and coarse aggregate", Korean Standards Association, 2010.
  12. KS F 2505, "Testing method for bulk density of aggregate and solid content in aggregate", Korean Standards Association, 2002.
  13. KS F 2511, "Testing method for amount of material finer than 0.08mm sieve in aggregate", Korean Standards Association, 2007.
  14. KS F 2403, "Standard Test Method of Making and Curing Concrete Specimens", Korean Standards Association, 2010.
  15. KS F 2405, "Standard Test Method for Compressive Strength of Concrete", Korean Standards Association, 2010.

Cited by

  1. Fine Aggregates Size Effect on Rheological Behavior of Mortar vol.16, pp.8, 2015, https://doi.org/10.5762/KAIS.2015.16.8.5636